ISIJ International
Online ISSN : 1347-5460
Print ISSN : 0915-1559
ISSN-L : 0915-1559
Regular Article
Heat and Acid Leach Treatments to Lower Phosphorus Levels in Goethitic Iron Ores
Michael John Fisher-WhiteRoy Randall LovelGraham Jeffrey Sparrow
著者情報
ジャーナル オープンアクセス

2012 年 52 巻 10 号 p. 1794-1800

詳細
抄録

Phosphorus associated with goethite in high-phosphorus (>0.10 mass% P) iron ores was lowered to below 0.075 mass% P with a heat treatment at 300 or 350°C for 1 h followed by a sulphuric acid (H2SO4) leach. This phosphorus removal was associated with a sample weight loss of 10–20 mass% due to dissolution of iron oxides. After heating at 900°C for 1 h, a sulphuric acid leach resulted in similar phosphorus removal but with dissolution of less than 3 mass% of the sample.
The weight losses in the leach are associated with phase changes of the phosphorus-containing goethite phase during heating. Heating at 300 or 350°C resulted in conversion of the goethite into an intermediate hematite phase (protohematite), while heating at 900°C gave a dense hematite phase. Compared with goethite in the ore, the more porous protohematite phase was more soluble in the sulphuric acid resulting in dissolution of iron with the phosphorus, while the dense hematite phase was much less soluble and little iron was dissolved in the leach.
Leaching at 25 mass% solids for 3 h at 60°C, at a pH of 0.5 or lower, gave significant lowering of phosphorus levels. Leaches were with 0.1–1M H2SO4; the concentration of acid required depended on the amount of phosphorus to be removed. Recycling of the acid leach liquor four times did not show evidence for precipitation of phosphorus and resulted in leach solutions with up to 1 g/L P and 134 g/L Fe.

著者関連情報
© 2012 by The Iron and Steel Institute of Japan
前の記事 次の記事
feedback
Top