日本エネルギー学会誌
Online ISSN : 1882-6121
Print ISSN : 0916-8753
ISSN-L : 0916-8753
論文
製パン工場から発生する有機性廃棄物のメタン発酵による再生エネルギー利用
清水 佐衣子松橋 隆治吉田 好邦
著者情報
ジャーナル フリー

2007 年 86 巻 1 号 p. 46-54

詳細
抄録

This study focuses on animal and plant residue, which is generated from the baking factory, and proposes the efficient use of the organic waste by the anaerobic digestion.
The energy recovery system uses generated methane gas from the baking factory. We evaluate the feasibility of the system by considering the economical efficiency and CO2 emission reduction potential.
As a result of proof test, 472Nm3 of biogas was obtained from a ton of the normal residue of baking factory. The methane density in the generated biogas was 64%. As for the usage of the biogas, we examined three cases: boilers to heat, generators to electricity, and co-generation to heat and electricity. Then, three cases are compared with the incineration of the residue from the viewpoint of CO2 emission reduction and economical efficiency.
It was found that the largest CO2 emission reduction was given by the co-generation system while the lowest cost was given by the boiler heating system.
Assuming that this system is subsidized by the Ministry of Agriculture, Forestry and Fisheries, half of the initial cost can be endowed. Then, the internal rate of return becomes 22.4 % in the case of the boiler heating system. This result indicates the boiler heating system is economically efficient from the usual investment standard. The co-generation system is also feasible under the subsidy since the internal rate of return of the co-generation system even reaches 13.0 %.

著者関連情報
© 2007 一般社団法人 日本エネルギー学会
feedback
Top