Tetsu-to-Hagane
Online ISSN : 1883-2954
Print ISSN : 0021-1575
ISSN-L : 0021-1575
The Kinds of Reactions in Coke Gasification by H2O
Yoshiaki KASHIWAYAKuniyoshi ISHII
Author information
JOURNAL FREE ACCESS

1993 Volume 79 Issue 12 Pages 1305-1310

Details
Abstract

Recently, in order to stabilize the blast furnace conditions, the vapour and/or pulverized coal are injected into blast furnace. The concentration of H2 in blast furnace increases above 8% in such a circumstance. Then it is so important to understand H2 behaviour in blast furnace.
In this study, gasification reaction of metallurgical coke by Ar-H2-H2O mixtures at 1273, 1473 and 1673K has been investigated. The measurement of reaction rate was carried out with gas analysis method using both of Quadrupole Mass Spectrometer (QMS) and Infrared gas analyser. The gas analysis method is so useful for not only the quantifying the reaction rate but also the estimating the kinds of reactions occurring in H2O-coke gasification. The consideration of the kinds of reactions were made by using the thermodynamic characterization of produced gas composition and the variation of the amount of each produced gases (H2, CO, CO2) according to reaction temperature. The kinds of reactions in the region above 1273K were elucidated.
In coke gasification by H2O, main reaction is water gas reaction I. The generation of CO2 is caused by water gas reaction II and the possibility of water gas shift reaction is very low. Further, owing to produced CO2, Boudouard reaction occurs and it becomes prominent in high temperature range.

Content from these authors
© The Iron and Steel Institute of Japan
Next article
feedback
Top