電気学会論文誌E(センサ・マイクロマシン部門誌)
Online ISSN : 1347-5525
Print ISSN : 1341-8939
ISSN-L : 1341-8939
特集論文
酸化防止層にSnを用いた低温Al-Al熱圧着ウェハレベル真空封止接合の研究
佐藤 史朗福士 秀幸江刺 正喜田中 秀治
著者情報
ジャーナル フリー

2016 年 136 巻 6 号 p. 237-243

詳細
抄録

This paper describes hermetic seal wafer bonding using Al covered with thin Sn as an antioxidation layer. The bonding temperature is below 400℃, which is the maximum temperature of CMOS-LSI backend process. Gas tightness over 3000 h at room temperature and sealing stability through heat treatment under a typical reflow condition of 260℃ for 10 min were confirmed for samples bonded at 370℃ and 380℃. A key for successful hermetic seal bonding is relatively high bonding pressure and stress concentration on sealing frames as narrow as several ten microns. The results of SEM and EDX analysis suggested that the bonding was due to direct Al-Al bonding, while Sn was diffused sparsely among Al grain boundaries. The developed bonding technology is usable for wafer-level integration of LSI and MEMS in conjunction with hermetic sealing.

著者関連情報
© 2016 電気学会
前の記事 次の記事
feedback
Top